version l edited on dec. 4, 2018 -1- h hitron universal ac input harmonic correction ac-dc 6u pen tad output 1000 watts vpx switching power supplies hav1000 ser ies features vita 62 compliant 6u 8hp or 10hp vpx power supply wide operating temperature range of -40c to +85 c internal or-ing diodes for n+1 redundancy active current sharing emi meet en 55032 / class a pmbus interface for status & control using 125c long life solid capacitors specification input general input voltage typical 90-264vac efficiency typical 89% at 230vac input frequency 47-63hz switching frequency 67-100khz input current 7.3a at 115vac dielectric withstand meet iec60950-1 regulation 5.2a at 230vac circuit topology zvs half-bridge circuit inrush current 37.2a(peak) at 230vac transient response peak transient < 600 & 10arms at 230vac recovers within 3ms after power factor typical 0.975 at 230vac 25% load-change input connector tyco 6450843-6 remote on/off available earth leakage current typical 1.1ma at 230vac power fail signal available no-load power typical 11.8watt at 115/230vac power ok signal available output dc ok signal available output connector tyco 6450843-6 n+1 redundancy internal or-ing diodes line regulation typical 0.5% power density 5.7-8.3watts/ cubic inch load regulation v1/v2/v3 typical 1.5% pmbus built-in v4/v5 typical 5% conformal coating available total regulation v1/v2/v3 typical 3% environmental v4/v5 typical 5% operating temperature -40 c to +85 c with de-rating noise & ripple typical 1.5% peak to peak storage temperature -45c to +90 c remote sense available at v1,v2 & v3 cooling 800lfm moving air adjustability available at v1,v2 & v3 humidity operating : 5-90 % ( non-condensing) current sharing available at v1, v2 & v3 storage: 0-95% (non-condensing) protection safety/emc over voltage built-in at all outputs emissions (conducted) en55032 / fcc class a over current built-in harmonic current iec61000-3-2 over load typical 110-150% maximum load safety standard iec 60950-1 class i fully protected against output ce standard meet level 3 criteria a over temperature installed ntc and thermostat vibration six degree-of-freedom random hold-up time 6.2-7.3ms at 115vac 10hz-150hz, 5g 2.3-2.8ms at 230vac notes: (1) all measurement are at nominal input, full load and +25c unless otherwise specifications. (2) due to requests in market and advances in techn ology, specifications subject to change without not ification. (3) a warm-up time 10 minutes is required after col d start at temperature from -40c to +0c. (4) tantalum capacitors connected to system is sugg ested for bettering ripple & noise against operatin g temperature from -40c to +0c. (5) 125c os-con long-life solid capacitors are ins talled in secondary circuits.
version l edited on dec. 4, 2018 -2- output voltage & current rating chart pentad output model no. volt. volt. min. typ. max. peak hav1000-p120edii-8hp v1 +12vdc 0.5a 40a/57a 70a 75a v2 +5vdc 0.5a 19a/27a 30a 30a v3 +3.3vdc 1.0a 12a/18a 25a 25a v4 +12vdc 0.1a 1a/1.5a 2a 2a v5 -12vdc 0.1a 1a/1.5a 2a 2a HAV1000-P120EDII-10HP v1 +12vdc 0.5a 44a/63a 70a 75a v2 +5vdc 0.5a 21a/30a 30a 30a v3 +3.3vdc 1.0a 14a/20a 25a 25a v4 +12vdc 0.1a 1a/1.5a 2a 2a v5 -12vdc 0.1a 1a/1.5a 2a 2a notes: (1) for 8hp version, the max. output power is <=65 0w at 90-180vac and 900watt at 180-264vac. (2) for 10hp version, the max. output power i s <=703w at 90-180vac and 1008watt at 180-264vac. (3) minimum load is strongly required when ps u do run. mechanical dimensions (all dimensions are in mm[inch]) hav1000-p120edii-8hp derating chart
version l edited on dec. 4, 2018 -3- mechanical dimensions (all dimensions are in mm[inch]) HAV1000-P120EDII-10HP derating chart pin assignment p0 p1 p0-p7 p0-p4 p0-p1 p1 p2 d1 d2 p3 p4 p5 p6 d3 d4 d5 d6 p7 p8 d7 d8 d9 p9 p10 l n g com vo3 3.3v aux. ps_rnt en com com vo2 p03 +5v vo2 p03 +5v n/a a0 sda sys rst com com com deg. i/p_ok vo1 p02 +12v vo1 p01 +12v c1 c2 c3 c4 c5 c6 c7 c8 c9 v3 +s inh n/a a1 scl vo5 -12v v2 cs v2 -s v2 +s b1 b2 b3 b4 b5 b6 b7 b8 b9 v3 -s fal vo4 +12v a2 sda n/a n/a n/a n/a a1 a2 a3 a4 a5 a6 a7 a8 a9 v3 cs n/a psu_r nt alert scl n/a v1 cs v1 -s v1 +s
|
